The system was originally designed such that the Venturi drew air before my preasure tank, it then went thru a coil of 100 feet of 1 inch water line (gave the air time to turn the iron into a solid), then into a filter bed. You are a wise man. The . Is the maintenance on this device something that can be done by a homeowner without the use of a plumber or water specialist? That said, you need a detailed water test, like this:
6.) Of course, it depends upon your water quality and amount of water used, but our Oxi-Gen systems average about $70.00 a year and the inFusion averages about $250.00 a year. Works perfectly. Before the filter we had .59 mg/L Iron and after installing this filter we are down to .02 mg/L Absolutely no odor or taste remains and no more stains. My cabin is an overnight rental and I need to stop the complaints about the water. My water specs are:
H2O2 is a good oxidizer but not a good disinfectant. Up to 11 ppm manganese
The iron filtration product link is: http://csih2o.com/products/iron-sulfur-filters/sidekick-single-tank-aeration-filter Thanks again for your article and any assistance you can provide.. John,
Since reading your article I dove a little deeper and found a new twist on the air/ozone filter, specifically designed to eliminate the issues you discussed. Up to 11 ppm manganese
Pouring H2O2 down the well is counter-productive. $700.00 + $130.00 shipping . ... Iron Defender Plus Air Injection AIIDP10 Fleck 5600SXT Iron Filter 3/4" Bypass. Any competing contaminants; and
Hello. The Iron Eater maintains an âair pocketâ in the top of the tank while the system is in service. Well, here we are with the same problem that has never been corrected and tons of money being spent on filters. What type of system do you suggest for us to purchase. Thanks. H2O2 ALWAYS works! My current setup just has a regular whf I have to swap every 4-6 months due to this sludge already. 12"x52" tank (Vortech OPTIONAL)
Fortunately I have plenty of water but for people where quantity of water is a issue it could be clearer on the amount of water used in the back flush, it's quite a lot of water for people with low water problems as well as bad water. Also to speak to your point about a higher pressure backwash... this would require upgrading a well pump for some folks and that is just a whole other can of worms. The Fleck 2.5 cubic foot 2510AIO iron filter with katalox light, as a single tank system is an efficient and cost effective system for the removal of iron, manganese and sulfur. $559.00. Looks like I should not have any issues with my system then? In theory, can I just hookup a container with H2O2 so that instead of air, I draw H2O2? Absolutely, just make sure you do it with a proportional injection system like this:
This is done once a month to clean the valve. Duraline Birm Iron Filter Installation Guide. And the bonus...NO CHEMICALS!!! I have heard so much different advice that I am left completely overwhelmed! Thanks for any help you can give us. This American Water Solutions unit is a top of the line â¦ The â¦ I also have the rotten egg smell (the smell decreased a bit by changing my water heater sacrificial anode). Instead of brine, the water softener valve draws air (which contains oxygen) into the media tank where it oxidizes the iron (allegedly). It is a well system. #2. Fleck 5600 12"x52" Whole House Filter System Catalytic Carbon 2 Cu.Ft Chloramine. YES
#4. Maybe, I should have called this ". Besides the 200-300 average per year what is the difference in cost between the h2o2 system and the chemical free air version. Please see our water results , .501 iron , .261 manganese, 290 hardness, 4.7 turbinity. Looks just like the picture posted (iron sludge), which means it is working! We are not sure if our new water conditioning system can handle the iron. © 2020 US WATER SYSTEMS INC ALL RIGHTS RESERVED. But, if you are a "glass half full person" you might think that is a small price to pay for awesome water. I've gone past 2 years, but then I have more to clean out. I have the nelson AIO system before my softener. Follow up: For some reason important information regarding iron levels did not make the cut, probably due to my use of parentheses. 4. pH level. 3. I presume that you have hydrogen sulfide or rotten-egg odor in your water. This complete Fleck 5600 SXT Well Water Air Iron Filter comes with: 1.0 cubic ft Iron Blend Great For Well Water With Iron Ships Loaded for easier installation 10×44â³ mineral tank Catalytic carbon is the absolute best choice:
It is a delightful surprise when you spend this much and are completely satisfied. This ideal if youâve upwards of 15 ppm iron in your water. We have a water softner and use both a 25 micron prefiler; 1 micron post filter and a 75 micron pre filter; 25 micron post filter. Fleck 2510SXT AIO Air Injection Valve. The rust filter is after the pressure tank. Iron Pro 2 (best iron filter for well water) If you are using well water then you need iron filer. © Abundant Flow Water. I am sure it has helped many avoid the problems related to air injection and saved people the money and headaches associated. When using oxygen alone, the oxidation process starts as soon as the oxygen touches the water. The Air Plus Air Injection Oxidizing Filter System, as a single tank system, is an efficient and cost effective system for the removal of iron and sulphur. 5.) You should also use proportional injection, like these systems:
It will use very little H2O2, but will be very effective. 1 cubic foot Filox... Salt and chemical free Up to 10 ppm iron Up to 6 ppm hydrogen sulfide Up to 2 ppm manganese 9 GPM service flow 15 GPM peak flow 10 GPM minimum required 12"x52" tank 1.5 cubic feet Chemsorb Air... Salt and chemical free Up to 15 ppm iron Up to 15 ppm hydrogen sulfide Up to 2 ppm manganese 2.8 GPM service flow 8 GPM peak flow 5 GPM minimum required 10"x54" tank 1 cubic foot Catalytic Carbon ... Salt and chemical free
The air is injected into the bottom of the tank. What is mpg? Fleck 5600SXT Iron Defender Air Injection AIID10 Iron Filter with 3/4" Bypass. Here it is again: The water has low pH of minus 4 ppm probably due to the cistern and iron levels of plus 5 ppm, also a hardness, nitrite and nitrate level of 0 ppm. Installation Instructions for Backwashing Systems with Fleck 2510 and 2510SXT. In fact, we currently are using that technology with our Smartphone app which gives us better control of the system. That said, the first step is to get a detailed laboratory water analysis: The AFWFilters AIS10-25SXT is a whole house oxidizing water filter that does not use chemicals for iron and sulfurâ¦ See More Photos at Amazon >>> The Air Injection Platinum 15 iron filter â¦ I have very hard water, a lot or iron and high alkalinity(9) which is leaving my plumbing and faucets with black build up inside. My well water has zero iron and zero manganese, hardness is about 22gpg, pH 7.5, TDS 450ppm, sulfides 3.7ppm. Fleck 5600 SXT Air Injection Iron Filter Eliminates High Iron & Rotten Egg Smell. 4.) So here are my questions:
Nelsen AIO. #1. Thanx
2. I am truly impressed!!! It can use ozone, but our tests show that is not as effective as using hydrogen peroxide (only for a few seconds each time it regenerates). Does anyone make an adapter? Eliminator Pro Plus Manual. That is a good idea, but it only solves part of the problem. Many are too small. I had my plumber install it, but as a DIYer, I could have easily installed this unit myself. The media typically gets replaced every 5 years or so. Curious! So will this occur regardless? The water was so orange that you couldn't tell if you flushed the toilet or not. 10×54â³ mineral tank. That's the million dollar question. We have a farm well. Fleck 5600SXT digital control valve DuraWater IRON EATER Air Injection Iron Filter The DuraWater iron eater air injection oxidizing system, as a single tank system, is an efficient and cost effective system for the removal of iron and sulphur. Fleck 2510 Air Injection Iron Filter Start Up Guide is available. The Iron Eater Air Injection Oxidizing Filter System, as a single tank system, is an efficient and cost effective system for the removal of iron and sulphur. 3/4â³ or 1â³ Plastic Bypass. Culligan put one of these on my well and my water smalls bad and is the color of milk. I'm on a well that produces 48mpg . Free shipping . The fleck 5600 would work but is made for a threaded tank and mine is a clamp type. The AIOâ¢ Air Injection Oxidizing Filter System, as a single tank system, is an efficient and cost effective system for the removal of iron and sulphur. The OXi-Gen Systemc will cost more than I am willing to spend. I was frustrated at first but came to understand the product did not fail, it simply required more maintenance than I was willing to give. Is it. I appreciate any insight /comments you can provide. As the water passes thru the air pocket, iron and Iron are oxidized. (My 20 micron cartridge filter worked fine With the old galvanized pressure tank.). System has been in for 1 month and working great, noticed and improvement in water quality and smell. document.getElementById("copyright_year").innerHTML = new Date().getFullYear(); Salt and chemical free Up to 10 ppm iron Up to 6 ppm hydrogen sulfide Up to 2 ppm manganese 11 GPM service flow 17 GPM peak flow 12 GPM minimum required 13"x54" tank 2 cubic feet Chemsorb Air... Salt and chemical free
Please see our water results , .501 iron , .261 manganese, 290 hardness, 4.7 turbinity. Sale. Then they may fail sooner. It doesnât reduce it, but ratherâ¦ eradicates the iron and sulfur. I feel like we are responsible to trouble shoot this instead of our service company. https://www.uswatersystems.com/us-water-lab-water-test.html. Mine does not it is like the water is pure seltzer water.
1877-477-5452 or email@example.com M-F 9am-5pm CST Toll Free Support During Installation & Programming!! 9.4 GPM minimum required
Currently there is no iron filtration in place, only one carbon sediment filter. Up to 17 ppm hydrogen sulfide
They type of iron;
Every solution KO proposes to an issue involves my checkbook for only a potential return of a 50% fix to the problem. I'm on a well that produces 48mpg . They say that is normal. I was told that with nightly backwashing the injector etc becoming clogged would not be an issue? Would you recommend katalox light media with hydrogen peroxide injection for iron removal or some other media like Carbon. For more on our Air Injection systems click here. We have the media replaced but it did not help. Highly recommended. We installed a Katalox tank with air injection almost 3 1/2 years ago, and the system has worked flawlessly without any maintenance other than a weekly backwash (yes, weekly, not daily as recommended). Filter, when properly applied, is an efficient and cost effective system for the removal of Iron and Sulphur. The average family spend $200 to $300 a year on H2O2. Duraline Air Injection Iron Filter Manual. The DuraWater Iron Eater system comes equipped with a Fleck 5600SXT air injection control head that automatically back washes the system daily to clean the media and flush everything down the drain. We usually have some type of sale in place which can save you a few hundred dollars. The electronic computer control cleans the chemsorb of accumulated contaminants while delivering clean, clear, fresh water throughout your home. But I am looking for a rust removal system for a well-sourced water supply (Florida coast) lawn irrigation application. If the head is broken, then the media is likely bad and the tank is a horrible design. Most AIP systems are nightmares, but our new OXi-Gen eliminates all those iron plugging problems: No Longer A Issue. It depends upon your perspective.
I find I have a lot of already oxidized material in the cistern that material is ending up in my iron filter and softerner head tends to coat everything with brown red slippery material Have quite high manganese , .734 ml/litre a bit of .188 iron ml /litre, ph 7.5 So from the cistern to the iron filter the pipes and the iron filter tends to give issues getting slined up on a fairly regular basis ! I would like to just go to a water softener only. https://www.uswatersystems.com/infusion-backwashing-filter-for-iron-sulfur-and-manganese-removal.html
I own a cabin on a mountain in West Virginia that uses a cistern system that feeds to the well. #5. If the glass sits for a minute, it should clear up. Les, The Air Plus maintains an âair pocketâ in the top of the tank while the system is in service. It uses all NSF and FDA approved components, including the media. I used to use a green sand filter which was costly to run and you always had to make sure you had enough potassium permanganate in the little side container which was annoying. I purchased KO's water softener and standard iron filter system when I built my home on the guise that this tiny municipal water plant would be the one and done solution to my water needs.
Yes, it puts a lot of air in the water. The AIOâ¢ maintains an âair pocketâ in the top of the tank while the system is in service. Just asking Thanx! He said that could have been causing the neutralizer not to work properly.
The recommended system uses hydrogen peroxide as the oxidizer. Any amount over 0.3 ppm will stain, so 2.0 ppm is a lot, but some people have 5 ppm, 10 ppm, 20 ppm, 50 ppm... and more. If you have very high levels of iron in your water, installing an air-injection iron filter. I would also need a lot more information about other competing contaminants. Your particular water chemistry very much comes into play. Our iron levels are at 7 ppm before treatment. You have to weigh the cost and if it is too much, I get that! Obviously, your article seems to state differently. I can say that I haven't used a furnace in 15 years, but if I live in Key West, what correlation is that to people who live in Alaska? 1" bypass (3/4" Bypass by request only) Media Pre-filled. That catalyst is the media. You hear "talk" and "rumors" about the water treatment industry being less than honorable and salespeople using trickery to get you to buy---not the case here! The answer depends upon several factors:
Should we have the AIO removed? https://www.uswatersystems.com/us-water-proportional-injection-tank-system-3-4.html
The best air injection we have picked is from Air injection Silver. Katalox will not work there. There are plenty of companies who will sell you a water softener that removes iron too... at least they say that. Thanks again for your article. Thank you -. Rebuild kit for the Fleck 2510 filter valve. The advantage of this type of air injection is that since the valve is on the side of the tank, it comes in contact with no air. #6. Here’s a blog that is an update to our new technology: https://www.uswatersystems.com/blog/air-injection-revisited. Salt does not harm concrete, unless it is expsed to it while frozen. Digital Filox 10 System Fleck 2510SXT Iron, Manganese, Sulfur, H2S water filter. My tubs,toilets and fixtures use to have reddish rusty stains from iron. There is no water softener in the system. So with my well! Probably, but I would like to know more about your water. We can’t seem to get our PH level up over 6.8 since we installed an AIO system 10 months ago along with a brand new water conditioning system. Thanks for the informative blog. Up to 17 ppm hydrogen sulfide
You hear "talk" and "rumors" about the water treatment industry being less than honorable and salespeople using trickery to get you to buy---not the case here! Typically, $200 to $300 of peroxide a year.
Abundant Flow Air Injection is $563.48 more expensive than an average water softener ($189). As the water passes â¦ One of the things they do is require the end user to stick the air inlet hose into a bucket of chlorine. It's in the top 3 bestselling water softeners and has many popular alternatives in the same price range, such as Fleck Iron Pro 48K or Nuvo Home Salt System. Read these reviews and took a chance! Perhaps go with the peroxide injection or change out the 100 feet of hose with a holding tank of sorts that won't clog, something similar to what Jorge used, just not aeration. Up to 27 ppm iron
Water is cleaner than i ever seen it and no smell. It appears we are injecting peroxide before the the filter head ! I have a clack WAS 5 buttons drawing air through the eductor which is indeed 21% O2 at sea level. The AIO control valve maintains a compressed âair pocketâ in the top of the tank while the system is in service. Since this does involve a product from another company it is fine with me if you choose not to post this but instead just reply to me directly through my email. The level of iron in ppm;
Please help me. Air injection can work, but it requires a lot of maintenance. Culligan promised that there system would take care of the problem. Up to 27 ppm iron
We collaborate with CSI on some projects. Water Testing by Professional Lab 35 Contaminants With Lead, Bodyguard Whole House Chemical Removal Filter by US Water Systems, US Water Systems All American 5 Stage Reverse Osmosis System, Sanidyne Prime Remote UV-C Portable Air And Surface Sanitizer, Sanitaire RSCS280A Recessed Ceiling Mount UV-C Air Sanitizer, Companies who build these "air-injection iron filters" utilize a water softener control which used a "nozzle and venturi" assembly, Instead of resin in the tank, these companies utilize media like Birm, Filox, Katalox, Pyrolox or Catalytic Carbon which provide an area for iron to oxidize; and. Fleck 9100 Manual. My softener is starting to allow more iron to pass through. As the water passes thru the air pocket, Iron and Sulphur are oxidized. Help! !Seems the complaint with other systems is the fouling of the equipment This seems to have not changed here! I followed the link for the equipment you suggested in a previous post but it is very expensive (https://www.uswatersystems.com/infusion-backwashing-filter-for-iron-sulfur-and-manganese-removal.html) Any advice? 25 Hardness / 3.6 ppm Iron / 7.5 pH / 930 ppm Total Dissolved Solids
7000SXT Service Manual. You need this before the softener:
I am tired of maintaining my pressurized air injector system. Free shipping . Hey, just want to make one comment regarding air injection. I would still recommend the use of UV to kill bacteria, although H2O2 will kill some. If you want to eradicate iron and/or sulfur, it is doubtful that an air injection filter will do that… especially after a few weeks. Air Injection Platinum 15. Doc! Hydrogen Peroxide is H2O2, while Oxygen is O2. Great job!!! I have it serviced every two years as instructed by my service provider and it works really well. 1. 2) Would a softener only 'kill two birds with one stone' -- take care of the hardness AND iron? When you have this air induction system is your water the color of milk? Our blog is a living, breathing thing, and when this post was written, we did not have the Flexx OXi-Gen – we were doing it the same way everyone else did. Will this device replace my current iron filter? Just wish I would have bought the peroxide system first time around and saved myself some time. Yes have to clean and maintain every couple of years, and the aerator has to be looked after, but definitely takes the load off the softerer. It will not hurt anything you mentioned. I guess I’ll have to resort to periodic power washing of the fence and house exterior unless you have another idea. The backwash system is working fine. 1.) What type of system do you suggest for us to purchase. https://www.uswatersystems.com/infusion-backwashing-filter-for-iron-sulfur-and-manganese-removal.html
Air Injection Silver systems provide low cost removal of iron, manganese, and hydrogen sulfide (sulfur or rotten egg odor) without chemical injection. Over 2 1/2 - 3 years the pressure tank, line from pressure tank to rust buster cylinder and '5 in 1' media bed inside cylinder are all pretty much plugged. 12 GPM peak flow
Covers air injection silver, gold, and platinum filter systems. #3. https://www.uswatersystems.com/flexx-oxi-gen-aeration-iron-and-sulfur-filter.html This is the solution for water with IRB or SRB: https://www.uswatersystems.com/flexx-infusion-iron-sulfur-and-manganese-removal-system.html or
Each line of equipment is built with top of the line engineered components. https://www.uswatersystems.com/us-water-lab-water-test.html
The Peroxide system always works. I'm not disagreeing that H2O2 is a better oxidizer, but I'm also not so sure that they will just sludge up like that unless something was done incorrectly. #8. Any ideas on what A guy can do in this case??? Fleck 5600 SXT Iron Filter. Feel free to call us at 800-608-8792 to get more info. Use stabilized OXi-PRO 7 H2O2 (because others degrade too fast):
maintains a compressed âair pocketâ in the top of the tank while the system is in service. Kit includes piston assembly and the seal & spacer kit (Fleck part# 61670-00). Opens image gallery. Dura Water Air Injection Iron eater Filter - Key â¦ Fleck, Duraline, birm and air injection iron filters. This complete IRON Eater Well Water Air Iron Filter comes with: 1.0 cubic ft Iron Blend Great For Well Water With Iron. I'm wondering how expensive is the H202 and what would be the aproximate rate of use? Just got our water analysis back from the lab and this filter has completely corrected our water. I would highly recommend this product to anyone that has a well. Dura Water Air Injection Iron eater Filter. Covers all standard backwashing systems, including ASM and AdEdge arsenic systems, carbon tanks, iron filters, ph tanks, and sediment tanks. Also, what is the correct order for all these things to be installed? I would recommend these: https://www.uswatersystems.com/bart-iron-and-sulfur-reducing-bacteria-tests.html
Picture Information. Logix Manual. That is one of the many reasons we do not use that type of AIO. We do offer an ozone option, so that you can introduce ozone (O3) instead of O2 into the tank for superior oxidation. A Patented air injection technology built into the control valve and a Check valve that keeps a pocket of pressurized air in the tank increase the capacity of the media to remove high levels of Iron, Manganese and Hydrogen Sulfide. I would like to see a good laboratory analysis, like this one: https://www.uswatersystems.com/us-water-systems-professional-lab-water-test.html. I cannot believe it! This product was shipped fast and really works. Each products is backed by a â¦ Should it be installed before or after the pressure tank but before the filter. https://www.uswatersystems.com/us-water-systems-professional-lab-water-test.html, I have 18 ppm iron . Really good instructions arrive with the unit or can be found on the AFW website. I do not want to be trying to clean that hunk out. Would you recommend this system? Thank You. The valve head is broken and parts are not available. I tried to talk to the good people at nelson about this and they say its normal to have a little air it should dissipate after 30 sec or so. Hello,
Call one of our Water Experts if you have questions. thanks. Was thinking going the O3 route instead then? Can't be a good thing??
The Fleck 2510 SXT Backwashing Filter is a fully automatic backwashing filtration system.
If you want to try one, let me know. By the time I called tech support they had discontinued the sales of air injection system for this very reason - a lot of customer call backs apparently.
Free shipping . we run through an air injector and then a chlorine injector to a 800 gallon holding tank from there as you use water it is drained to another 800 gallon tank but when first tank refills and you are drawing on second tank you don't always get settled water due to water coming in first tank mixing with settled water needing a way to to filter water going to second tank because after second tank we have two iron filters and a softener that can do the job of filtering settled water but not the remixing of the water during long draw times. I want to see a good detailed water test like the one in the link I attached. Which device/application would be the best solution to effectively remove iron-oxidizing and iron-reducing bacteria at a minimum of a 95% success rate? The Nelsen AIO ® Air Injection Oxidizing Filter System, as a single tank system, is an efficient and cost effective system for the removal of Iron and Sulphur. $519.00. Receive 5% Off your first order when you subscribe! Sadly, this has not been the case and it is because of what appears to be iron bacteria is present in my water supply based on the yellowish residue left over on sinks, shower heads clogging up every two-three weeks, and a light film in the bowl of the toilet and back of the toilet. 6.5 GPM minimum required